CONTACT-US

TEREX Accessories shares with you how to maintain the battery? It’s too late to watch when you lose power.

 TEREX accessories are insignificant compared with large batteries such as engines, but they also need to be carefully loved by friends. Some friends began to pay attention to battery maintenance in case of power loss and other accidents, which is bad for batteries.

❑ Power loss will lead to the need for early detection and prevention of battery vulcanization

If the battery loses power (the open circuit terminal voltage is lower than 12.3V), it will lead to battery vulcanization, serious power failure, and even battery scrap. The battery is powered off, i.e. the battery is deeply discharged. When discharging, sulfuric acid and lead plate will produce lead sulfate. If not charged in time, lead sulfate will crystallize. If the crystallization time is long, it will not decompose after charging. This process is the sulfation of the battery.

How can Cardmate find out in advance whether the battery has lost power? Generally speaking, the battery power loss mainly has the following omens:

1. Difficulty in starting the vehicle

Without other factors, if the vehicle is suddenly difficult to start, the battery may fail. Of course, if it is winter, it may be because cold start is difficult.

2. The light is dim when the vehicle is idling

When the vehicle is temporarily stopped, the headlights of the vehicle suddenly turn dark, which is also a precursor of battery failure. It is recommended that the charging power of the engine decreases when idling, and the battery needs to supply power for other equipment in the vehicle. The headlamp pack consumes a lot of power. If the battery power is insufficient at this time, the light will be dim.

❑ There are various reasons for power loss, and the battery needs to be replaced seriously

The battery power shortage of TEREX accessories is mainly attributed to the poor driving habits of the car owner, the battery or the vehicle itself.

For car owners, the air conditioner is not turned off before the engine is turned off, and they forget to turn off the lights after the engine is turned off. They often charge other equipment after the engine is turned off. Bad habits such as repeated starting or ignition in a short time will cause great damage to the battery.

For the battery and the vehicle itself, it will be consumed if the vehicle is left for too long, the generator is damaged, the service life expires, the electrolyte is insufficient, the battery pile head is corroded, the cable connection is loose, the iron is poor, and the battery or vehicle circuit leaks electricity.

Once the battery is powered off, it is difficult for the vehicle to start. At this time, if the vehicle starts hard, it will have a great impact on the battery life. If the battery voltage is lower than 9, the charger should be used to charge V in time. After charging, the battery cannot be recovered after repair, and a new battery needs to be replaced. If the charger can still be charged, do not replace it with a new battery.

❑ How to avoid daily inspection and maintenance of battery power loss?

In order to prevent the battery from powering off, Carfriend needs to pay attention to the following points during daily use:

1. When the ammeter pointer indicates that the battery is low, it needs to be charged in time

If Cardmate finds that the power supply is insufficient and the engine cannot be started during driving, he can ask other vehicles around for help and borrow the battery on other vehicles to start.

2. Timely replenish distilled water or liquid

If the electrolyte of non maintenance free battery is lost, it is necessary to replenish distilled water or liquid in time. Remember not to use purified drinking water instead, because the purified water contains many trace elements, which will have adverse effects on the battery. The maintenance free battery does not involve electrolyte supplement, and external maintenance is required.

3. Avoid using the starter continuously when starting the vehicle

Continuous use of the starter will cause damage to the battery due to excessive discharge. The total time of starting the vehicle each time shall not exceed 5 seconds, and the interval of restarting shall not be less than 15 seconds. If the vehicle cannot be started after multiple starts, the causes shall be found out from the circuit, ignition coil, oil circuit, etc.

4. Avoid not using the battery for a long time

The battery does not need to be discharged slowly for a long time until it is scrapped. When parking for a long time, start for about 20 minutes every 15 days to charge the battery. If it is necessary to stop the vehicle for more than 15 days, disconnect the negative pole connection of the battery so that the battery circuit can not form a circuit and the power consumption is significantly reduced.

5. Avoid false connection of battery pile head

If the battery pile head is not fastened, an oxide layer will be formed between the pile head and the clip, which may lead to virtual connection of the battery and affect vehicle starting and battery charging.

During daily inspection and maintenance, Caryou can pay more attention to the following aspects:

1. Frequently check whether the small hole on the battery cover is ventilated

If the small hole on the battery cover of TEREX accessories is blocked, the hydrogen and oxygen generated inside cannot be discharged. When the electrolyte expands, the battery shell will crack, affecting the battery life.

2. Frequently check whether the positive and negative electrodes of the battery are oxidized

In order to avoid oxidation of the electrode, Caryou can water one more wire connection with hot water.

3. Frequently check whether the circuit and other parts are aged or short circuited

Check the vehicle circuit regularly to prevent the battery from being damaged due to excessive discharge.

*Disclaimer: The reprinted content comes from the network. If you have any objection, please contact us in time, and we will delete it..